OLYMPIC OIL LTD -- ACE PNEUMATIC TOOL OIL  -- 9150-00N093569
<pre>=====================  Product Identification  =====================

Product ID:ACE PNEUMATIC TOOL OIL
MSDS Date:10/23/1996
FSC:9150
NIIN:00N093569
Status Code:A
=== Responsible Party ===
Company Name:OLYMPIC OIL LTD
Address:5000 W 41ST ST
City:CICERO
State:IL
ZIP:60804
Country:US
Info Phone Num:708-458-8500
Emergency Phone Num:708-458-8500
Resp. Party Other MSDS Num.:MSOL125
CAGE:0WSZ9
=== Contractor Identification ===
Company Name:OLYMPIC OIL LTD
Address:5000 W 41ST ST
Box:City:CICERO
State:IL
ZIP:60804
Country:US
Phone:708-458-8500
CAGE:0WSZ9

=============  Composition/Information on Ingredients  =============

Ingred Name:REFINED PETROLEUM OIL (MIXTURE OF 64742-53-6 AND/OR
    64742-52-5).
= Wt:95.

Ingred Name:TALL-OIL FATTY ACIDS (ACUTE ORAL (RAT) LD50 (760MG/KG AND
    >10,000 MG/KG).
CAS:61790-12-3
&lt; Wt:3.

Ingred Name:PREMIUM ANTI WEAR ADDITIVE MIXTURE (6259-15-8) ADDITIVE
= Wt:.1

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: NO IRRITATION IS EXPECTED
    FROM SHORT TERM EXPOSURE. SKIN : MILD IRRITATION MAY OCCUR UPON
    SHORT TERM EXPOSURE. INGESTION: NO SIGNIFICANT ADVERSE HEALTH
    EFFECTS ARE EXPECTED TO OCCUR UNDER  NORMAL CONDITIONS OF USE.
    HOWEVER, EXPOSURE TO PETROLEUM MIST AT HIGH LEVELS MAY BE
    IRRITATING TO THE NOSE, THROAT AND LUNGS. CHRONIC: SKIN: MAY CAUSE
    MILD SKIN IRRITATION AND INFLAMMATION FOLLOWING E XTENDED CONTACT. 
    USED OIL MAY BE HARMFUL TO SKIN!
Explanation of Carcinogenicity:LABORATORY STUDIES SPONSORED BY THE
    AMERICAN PETROLEUM INSTITUTE SHOW MICE DEVELOP SKIN CANCER
    FOLLOWING REPEATED APPLICATION & CONTINUOUS EXPOSURE TO A USED
    MOTOR OIL COMPOSITE.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:MAY AGGRAVATE PRE-EXISTING
    RESPIRATORY CONDITIONS.

=======================  First Aid Measures  =======================

First Aid:EYES: FLUSH W/CLEAN, LOW PRESSURE WATER FOR AT LEAST 15 MIN,
    OCCASIONALLY LIFTING THE EYELIDS. IF PAIN/REDNESS PERSISTS AFTER
    FLUSHING OBTAIN MED ATTN. SKIN: REMOVE BY WIPING; THEN WASH SKIN
    THOROUGHL Y W/PLENTY OF SOAP & WATER. REMOVE CONTAMINATED CLOTHING
    & THOROUGHLY CLEAN BEFORE REUSE. DISCARD CONTAM LEATHER GLOVES &
    SHOES. INGEST: IF MORE THAN HALF-CUP FULL OF MATERIAL IS SWALLOWED,
    GIVE QUANT ITIES OF WATER, DO NOT INDUCE VOMITING, & OBTAIN MED
    ATTN. INHAL: VAPORIZATION IS NOT EXPECTED & AMBIENT TEMP &	MATL IS
    NOT EXPECTED TO BE AN INHAL PROBLEM UNDER ANTICIPATED CONDITIONS OF
    USE. IN CAS E OF OVEREXPOS, (SUP DAT)

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:=163.9C, 327.F
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:DRY CHEMICAL AND CARBON DIOXIDE. FOAM AND WATER FOG
    ARE EFFECTIVE, BUT MAY CAUSE FROTHING.
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
    APPARATUS & FULL PROT EQUIP . OSHA-NFPA CLASS-IIIB COMBUSTIBLE
    LIQUID. FOR FIRES INVOLVING THIS MATL, DO NOT ENTER ANY ENCLOSED OR
    CONFINED FIRE SPACE  W/O PROPER PROT EQUIP. THIS MAY INCLUDE SCBA
    TO PROTECT AGAINST HAZARDOUS EFFECTS OF COMBUSTION (UNUSUAL FIRE &
    EXPLO)
Unusual Fire/Explosion Hazard:BURNING OR EXCESSIVE HEATING MAY PRODUCE
    CARBON MONOXIDE AND OTHER HARMFUL GASES/VAPORS INCLUDING OXIDES
    &/OR OTHER COMPOUNDS OF ZINC, SULFUR &  PHOSPHORUS. FIREFIGHT: PROD
    & OXYGEN DEFICIENCIES. IF F IREFIGHTERS CANNOT WORK UPWIND TO FIRE,
    RESP PROT EQUIP MUST BE WORN. COOL TANKS & CONTAINERS EXPOSED TO
    FIRE W/WATER.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL SPILL: ABSORB SPILL W/INERT MATERIAL
    (E.G. DRY SAND/EARTH), THEN PLACE IN A CHEMICAL WASTE CONTAINER. LG
    SPILL: CONTAIN SPILL & PREVENT IT FROM ENTERING ALL WATER BODIES,
    IF POSSIBLE. SAFELY STO P FLOW OF SPILL. EVACUATE NON-ESSENTIAL
    PERSONNEL FROM IMMEDIATE SPILL AREA DUE TO SLIPPING HAZARD. IN
    URBAN AREA, CLEANUP AS SOON AS POSSIBLE; IN NATURAL ENVIRONMENTS,
    CLEANUP ON ADVICE (OTHER INFO)

======================	Handling and Storage  ======================

Handling and Storage Precautions:HANDLING: KEEP AWAY FROM HEAT, SPARKS
    & FLAME. USE OF OIL IMPERVIOUS GLOVES RECOMMENDED. STORAGE: TO
    AVOID PRODUCT DEGRADATION, WATER CONTENTION SHOULD BE AVOIDED &
    MINIMUM FEASIBLE HANDLING TEMP SHOU LD BE MAINTAINED. PERIODS OF
    EXPOSURE TO HIGH TEMP (GT 200F) SHOULD BE MINIMIZED. (OTHER PREC)
Other Precautions:HANDLING/STORAGE: PRODUCT DEGRADATION MIGHT INCREASE
    HEALTH HAZARD RISKS. STORAGE TEMPERATURE: AMBIENT. STORAGE
    PRESSURE: ATMOSPHERIC. KEEP OUT OF REACH OF CHILDREN. AVOID
    PROLONGED AND/OR /REPEATED S KIN CONTACT. WHEN CONTACT OCCURS, WASH
    PROMPTLY TO REMOVE.  WASH THOROUGHLY AFTER HANDLING.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE IS NEEDED UNDER ANTICIPATED USE CONDITIONS
    WITH ADEQUATE VENTILATION. IF EXPOSURE EXCEEDS THE OCCUPATIONAL
    EXPOSURE LIMITS, FOLLOW OSHA STANDARDS OR EQUIVALENT AND WEAR
    PROPER NIOSH APPROVED REPI RATORY EQUIPMENT.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
    BELOW APPLICABLE GUIDELINE(S)/STANDARD(S).
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGS & FULL LENGTH
    FACESHIELD . (SUP DAT)
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH AND DELUGE
    SHOWER . WEAR IMPERVIOUS PROTECTIVE CLOTHING.
Work Hygienic Practices:WHEN LEAVING WORK, WASH HANDS/EXPOSED SKIN
    W/SOAP & WATER. AVOID PROLONGED &/OR RPTD SKIN CONTACT. WHEN
    CONTACT OCCURS, WASH PROMPTLY TO REMOVE. GET MEDICAL ATTENTION FOR
    ANY PERSISTENT SKIN PROBLEMS.
Supplemental Safety and Health
FIRSTAID: MOVE PERSON TO FRESH AIR. NOTE TO MD: SUPPORTIVE CARE.
    TREATMENT BASED ON JUDGEMENT OF MD RESPONSE TO PATIENT. MAY
    AGGRAVATE PRE-EXISTING RESP COND. EYE PROT: WEAR EYE PROT IN
    LIKELIHOOD OF  SPLASH/SPRAY & ESPECIALLY IF MATL IS HOT (GT 125F),
    WEAR GOGGS &/OR FCSHLD.  HARD CONTACT LENSES MUST NOT BE WORN.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:N/D
Vapor Pres:N/D
Vapor Density:(AIR = 1)
Spec Gravity:0.89
Viscosity:22-26
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT BROWN LIQUID, SLIGHT PETROLEUM ODOR.
Percent Volatiles by Volume:NEGLIGIBLE

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALIS AND OXIDIZERS SUCH AS LIQUID CHLORINE AND OXYGEN.
Stability Condition to Avoid:AVOID EXTREME HEAT AND OPEN FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER HARMFUL
    GASES/VAPORS INCLUDING OXIDES AND/OR OTHER COMPOUNDS OF ZINC,
    SULFUR AND PHOSPHOROUS.

===================  Toxicological Information	===================

Toxicological Information:EYE/ACUTE ORAL: NO SIGNIFICANT ADVERSE HEALTH
    EFFECTS ARE EXPECTED TO OCCUR UPON SHORT TERM EXPOS. SKIN: MILD
    IRRIT MAY OCCUR UPON SHORT TERM EXPOS. ACUTE INHAL: NO SIGNIFICANT
    ADVERSE HEALTH EFFECT A RE EXPECTED TO OCCUR UNDER NORM COND OF
    USE. HOWEVER, EXPOS TO PETROLEUM MIST AT HIGH LEVELS MAY BE IRRIT
    TO NOSE, THROAT, LUNG. CHRONIC: LAB STUDIES SPONSORED BY AMERICAN
    PETROLEUM INST SHOW MICE DEV ELOP SKIN CANCER AFTER RPTD APPLIC &
    CONTINUED EXPOS TO USED MOTOR OIL COMPOSITE. AVOID CONTACT W/USED
    MOTOR OIL. PERSONS W/PRE-EXISTING SKIN DISORDERS SHOULD AVOID CONT
    W/PROD. MUTAGENICITY: NO DATA.  BIRTH DEFECT/REPROD INFO: NONE
    KNOWN.

=====================  Ecological Information  =====================

Ecological:THE SPILLED MATERIAL AND ANY SOIL OR WATER WHICH IT HAS
    CONTAMINATED MAY BE HAZARDOUS TO ANIMAL/AQUATIC LIFE. WASTE
    DISPOSAL: IF SPILL IS INTRODUCED INTO A WASTE-WATER TREATMENT
    SYSTEM, CHEMICAL & BIO LOGICAL OXYGEN DEMAND WILL LIKELY INCREASE.
    SPILL MATERIAL IS BIODEGRADABLE IF GRADUALLY EXPOSED TO
    MICROORGANISMS. POTENTIAL TREATMENT AND DISPOSAL METHODS INCLUDE
    LAND FARMING, INCINERATION AND LAND  DISPOSAL, IF PERMITTED.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
    FEDERAL REGULATIONS . MAXIMIZE PRODUCT RECOVERY FOR
    REUSE/RECYCLING. CONDITIONS OF USE MAY CAUSE THIS MATL TO BECOME A
    "HAZARDOUS WASTE" AS DEFINED BY S TATE OR FEDERAL LAW. USE APPROVED
    TREATMENT, TRANSPORTERS & DISPOSAL SITES IN COMPLIANCE W/ALL APPLI
    CABLE LAWS. (SEE ECOLOGICAL INFO)

===================  MSDS Transport Information  ===================

Transport Information:DOT HAZARDOUS MATERIALS PROPER SHIPPING NAME: NOT
    A D.O.T. "HAZARDOUS MATERIAL". DOT HAZARD CLASS: NOT REGULATED.
    UN/NAID NO.: NOT REGULATED.

=====================  Regulatory Information  =====================

SARA Title III Information:SECTION 311/312 HAZARD CATEGORIES: IMMEDIATE
    (ACUTE) AND DELAYED (CHRONIC) HEALTH HAZARDS.
Federal Regulatory Information:TOXIC SUBSTANCE CONTROL ACT (TSCA): ALL
    COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. 
    COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION & LIABILITY ACT
    (CERCLA): NO CHEMICALS IN THIS  PRODUCT ARE SUBJECT TO THE
    REPORTING REQUIREMENTS CERCLA.
State Regulatory Information:CALIFORNIA SAFE DRINKING WATER & TOXIC
    ENFORCEMENT ACT OF 1986 - PROPOSITION 65: BASED ON INFO CURRENTLY
    AVAIL, THIS PROD IS NOT KNOWN TO CONTAIN CHEMICAL CURRENTLY LISTED
    AS CARCINOGENS OR REPRODUCTI VE TOXINS UNDER CA PROP 65 AT LEVELS
    WHICH WOULD BE SUBJECT TO THE PROPOSITION. IF YOU REFORMULATE OR
    FURTHER PROCESS THIS PROD, YOU  SHOULD FURTHER EVALUATE THIS PROD
    HAZARD UPON SUCH REFORMULATION/P ROCESSING, AS WELL AS UPON ITS
    FINAL COMPOSITION AND USE.

=======================  Other Information  =======================

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.